Comparison of thermal and light performance in two typical Chinese solar greenhouses in Beijing

Fan Xu, Chao Shang, Hongling Li, Xuzhang Xue, Weituo Sun, Hong Chen, Yinkun Li, Zhenhe Zhang, Xinxu Li, Wenzhong Guo

Abstract


Solar greenhouses have been used for producing vegetables in northern China during early spring, late autumn or over-winter. To improve the thermal performance of solar greenhouses, a traditional type and a retrofitted design were comparatively evaluated. In the retrofitted design, three adjustments were incorporated: the material and structure of the walls, south-facing roof angle, and structure of the north-facing back-roof. The results indicated that the thermal and light performance of the retrofitted greenhouse was much better than that of the traditional greenhouse. Specifically, the daily mean temperature, minimum air temperature, and soil temperature inside the greenhouses after retrofit ting were increased by 1.3, 2.4, and 1.9°C, respectively, meanwhile, the daily total solar radiation and PAR were increased by 28.2% and 9.2%, respectively. The wall temperature and its daily variation range were reduced with increasing depth and height. The characteristic analysis of heat storage and release indicated that higher locations have longer heat storage, and shorter heat release time in vertical direction, as well as a lower ratio of heat release to storage. In horizontal direction, the western wall has the shortest heat storage time but the highest heat release flux density. Altogether, the heat storage time of the wall is 1.5 h less than that of the soil. The heat storage flux density of the wall is 1.5 times of that of the soil, but the heat release flux is only 61% of the soil’s value. The total wall heat storage is half of that of the soil in the greenhouse; the total wall heat release amount is only a quarter of that of the soil. Therefore, the thermal environment of solar greenhouses can be further improved by improving the thermal insulation properties of the wall.
Keywords: structural change, heat storage performance, heat flux, back wall, thermal environment
DOI: 10.25165/j.ijabe.20191201.3829

Citation: Xu F, Shang C, Li H L, Xue X Z, Sun W T, Chen H, et al. Comparison of thermal and light performance in two typical Chinese solar greenhouse in Beijing. Int J Agric & Biol Eng, 2019; 12(1): 24–32.

Keywords


structural change, heat storage performance, heat flux, back wall, thermal environment

Full Text:

PDF

References


Fang H, Yang Q, Zhang Y, Sun W, Lu W, Liang H. Performance of a solar heat collection and release system for improving night temperature in a Chinese solar greenhouse. Applied Engineering in Agriculture, 2015; 31(2): 283–289.

Chai L, Ma C, Ni J Q. Performance evaluation of ground source heat pump system for greenhouse heating in northern China. Biosystems Engineering, 2012; 111(1): 107–117.

Chai L, Wang B, Liu M, Wu Z, Xu Y. Dual-roof solar greenhouse—a novel design for improving the heat preserving capacity in Northern China. Natural Resources, 2014; 5(12): 681.

Li M, Wei X M, Qi F, Zhou C J. Research progress in wall of solar greenhouses. Xinjiang Agricultural Sciences, 2014; 51(6): 1162–1170, 1176. (in Chinese)

Sun S J, Zhan C H, Yang G, Yu Y G. Research on a new technology integrated low-cost, near-zero-energy solar greenhouse. Procedia Engineering, 2016; 145: 188–195.

Narjes D, Leila D. Experimental heat flux analysis of a solar wall design in Tunisia. Journal of Building Engineering, 2016; 8: 70–80.

Prashant S C, Anil K. Performance analysis of greenhouse dryer by using insulated north-wall under natural convection mode. Energy Reports, 2016; 2: 107–116.

Luo W. Changing characteristics of internal environment in the north energy-saving solar greenhouses. Harbin: Northeast Agricultural University, 2015. (in Chinese)

Wu F F, Tana, Bi Y G, Wang Y L, Zhou Y J. Study on the influence of the north wall structure on the temperature field inside greenhouse. Journal of Inner Mongolia Agricultural University: Natural Science Edition, 2015; 4: 100–104. (in Chinese)

Wei B, Guo S R, Wang J, Li J, Wang J W, et al. Thermal performance of single span greenhouses with removable back walls. Biosystems Engineering, 2016; 141: 48–57.

Zhang J, Wang J, Guo S R, Wei B, He X L, Sun J, et al. Study on heat transfer characteristics of straw block wall in solar greenhouse. Energy and Buildings, 2017; 139: 91–100.

Wang J W, Li S H, Guo S R, Ma C W, Wang J, Sun J. Analysis of heat transfer properties of hollow block wall filled by different materials in solar greenhouse. Engineering in Agriculture, Environment and Food, 2016; S1881836616300398.

Guan Y, Chen C, Han Y Q, Ling H S, Yan Q Y. Experimental and modeling analysis of a three-layer wall with phase-change thermal storage in a Chinese solar greenhouse. Journal of Building Physics, 2015; 38(6): 548–559.

Yang X L. Thermal environment testing and simulation of Chinese solar greenhouse with brick-polystyrene board compound wall. Yangling: Northwest A&F University, 2014. (in Chinese)

Song D. Research on soil wall of solar greenhouse and simulation of its temperature environment. Yangling: Northwest A&F University, 2013. (in Chinese)

Huang X. Studies on variation of soil wall temperature and heat flux in sunken solar greenhouse. Tai’an: Shandong Agricultural University, 2013. (in Chinese)

Huang X, Wang X F, Wei M, Hou J L, Liu FS, Li Q M, et al. Variation patterns of soil wall temperature and heat flux in sunken solar greenhouse. Journal of Applied Ecology, 2013; 24(6): 1669–1676. (in Chinese).

Zhang X G. The quantitative analysis of wall and soil heat storage in solar greenhouse. Taigu: Shanxi Agricultural University, 2015. (in Chinese)

He F, Zhou C J. Analysis on test of wall temperature distribution and heat flux in soar greenhouse. Northern Horticulture, 2015; (10): 58–61. (in Chinese)

Peng D L, Yang Q C, Wei L L, Zhang Y, Fang H. Measurement and heat flux analysis on north earthen wall in Chinese solar greenhouse. Chinese Journal of Agro-meteorology, 2014; 35(2): 168–173. (in Chinese)

Wang Q, Chen J L, Sun Z Q, Zhao Y, Wu M Z, Yang X T, et al. Heat flux analysis of inner surface of north wall in solar greenhouse. Chinese Journal of Agro-meteorology, 2012; 2: 225–229. (in Chinese)

Shi Y L, Wang X F, Wei M, Li Q M, Liu F S, Hou J L. Temperature variation, heat storage and heat release characteristics of soil wall in solar greenhouse. Transactions of the Chinese Society of Agricultural Engineering, 2016; 32(22): 214–221. (in Chinese)

Li J S, Bai Q, Zhang Y H. Analysis on measurement of heat absorption and release of wall and ground in solar greenhouse. Transactions of the Chinese Society of Agricultural Engineering, 2010; 26(04): 231–236. (in Chinese)

Ma C W, Bu Y L, Ji X H, Lu H, Zou L, Wang Y, et al. Method for calculation of heat release at night and evaluation for performance of heat preservation of wall in solar greenhouse. Journal of Shanghai Jiaotong University (Agricultural Science), 2008; 5: 411–415. (in Chinese)

Zhang Z L. Study on the heat transfer characteristics of sunken solar greenhouse soil wall of. Zhengzhou: Henan Agricultural University, 2012. (in Chinese)

Li M, Zhou C J, Wei X M. Thickness determination of heat storage layer of wall in solar greenhouse. Transactions of the CSAE, 2015; 31(2): 177–183. (in Chinese)

Hassan G M, Yahya A, Seyed F R, Mansour M. Solar energy conservation in greenhouse: thermal analysis and experimental validation. Renewable Energy, 2016; 96: 509–519.




Copyright (c) 2019 International Journal of Agricultural and Biological Engineering



2023-2026 Copyright IJABE Editing and Publishing Office