Effects of droplet size and spray volume parameters on droplet deposition of wheat herbicide application by using UAV

Changfeng Shan, Guobin Wang, Haihong Wang, Yingjie Xie, Huizheng Wang, Shilong Wang, Shengde Chen, Yubin Lan

Abstract


With the characteristic of flexible and precise, unmanned aerial vehicles (UAVs) for low volume applications are increasing substantially and quickly around the globe. However, little attention has been paid to the study of wheat herbicides with UAV, especially the research on the spray volume and droplet size of the herbicide sprayed by UAVs. The objectives of this study were to compare the droplet deposition from a typical commercial UAV under four different spray volumes of 7.5 L/hm2, 15.0 L/hm2, 22.5 L/hm2, and 30.0 L/hm2 and three different volume median diameter (VMD) of 150 μm, 200 μm, and 300 μm during winter wheat weeding period. DepositScan software was used to analyze droplet deposition parameters including the percentage of spray coverage and the number of droplets in various sampling positions. The test results showed that the droplet deposition was effected by each factor and their interactions. When the spray volume was 7.5 L/hm2, the effect of VMD on the percentage of spray coverage was not significant. However, these variation rules were changed to smaller droplets with greater coverage when the spray volume higher than 15.0 L/hm2. In all treatments, the number of droplets increased with decreasing VMD or increasing spray volume. The maximum percentage of spray coverage and the number of droplets that were achieved under the VMD of 150 μm and the spray volume of 30.0 L/hm2 were 12.8% and 40.0 droplets/cm2, respectively. The variation coefficients of the percentage of spray coverage and the number of droplets were 29.0%-73.3% and 20.2%-54.1%, respectively. The most uniform deposition was achieved under the spray volume of 15.0 L/hm2 and the VMD of 150 μm. The results revealed the effect of droplet size and spray volume parameters on droplet deposition, which was useful for guiding farmers on how to use UAVs for weeding in winter wheat fields.
Keywords: unmanned aerial vehicle, spray volume, droplet size, droplet deposition
DOI: 10.25165/j.ijabe.20211401.6129

Citation: Shan C F, Wang G B, Wang H H, Xie Y J, Wang H Z, Wang S L, et al. Effects of droplet size and spray volume parameters on droplet deposition of wheat herbicide application by using UAV. Int J Agric & Biol Eng, 2021; 14(1): 74–81.

Keywords


unmanned aerial vehicle, spray volume, droplet size, droplet deposition

Full Text:

PDF

References


Ahmad F, Qui B J, Dong X Y, Ma J, Huang X, Ahmed S, et al. Effect of operational parameters of UAV sprayer on spray deposition pattern in target and off-target zones during outer field weed control application. Computers and Electronics in Agriculture, 2020; 172: 105350. doi: 10.1016/j.compag.2020.105350.

Wang G B, Lan Y B, Yuan H Z, Qi H X, Chen P C, Ouyang F, et al. Comparison of spray deposition, control efficacy on wheat aphids and working efficiency in the wheat field of the unmanned aerial vehicle with boom sprayer and two conventional knapsack sprayers. Applied Sciences, 2019; 9(2): 218. doi: 10.3390/app9020218.

Chen Y, Qi H X, Li G, Lan Y B. Weed control effect of unmanned aerial vehicle (UAV) application in wheat field. Int J Precis Agric Aviat, 2018; 1(1): 25–31.

Yang S L, Yang X B, Mo J Y. The application of unmanned aircraft systems to plant protection in China. Precision Agriculture, 2018; 1(2): 278–292.

Lan Y B, Chen S D. Current status and trends of plant protection UAV and its spraying technology in China. Int J Precis Agric Aviat, 2018; 1(1): 1–9.

Chen S D, Lan Y B, Zhou Z Y, Ouyang F, Wang G B, Huang X, et al. Effect of droplet size parameters on droplet deposition and drift of aerial spraying by using plant protection UAV. Agronomy, 2020; 10: 195. doi: 10.3390/agronomy10020195.

Meng Y H, Han Y X, Liang Z, Su J, Lan Y B. Harvest-aid application strategy in different cotton planting densities using UAV: Effects of dosage and application frequency on defoliation efficacy, boll opening rate, fiber quality, and lint cotton yield. Int J Precis Agric Aviat, 2019; 2(1): 31–41.

Hunter J E, Gannon III T W, Richardson R J, Yelverton F H, Leon R G. Integration of remote-weed mapping and an autonomous spraying unmanned aerial vehicle for site-specific weed management. Pest Management Science, 2020; 76(4):1386–1392.

Qin W C, Qiu B J, Xue X Y, Chen C, Xu Z F, Zhou Q Q. Droplet deposition and control effect of insecticides sprayed with an unmanned aerial vehicle against plant hoppers. Crop Protection, 2016; 85: 79–88.

Martinez G J, Agüera P, Agüera J, Pérez-Ruiz M. Spray and economics assessment of a UAV-based ultra-low-volume application in olive and citrus orchards. Precision Agriculture, 2020; 21(1): 1–18.

Wang G B, Lan Y B, Qi H X, Chen P C, Hewitt A, Han Y X. Field evaluation of an unmanned aerial vehicle (UAV) sprayer: Effect of spray volume on deposition and the control of pests and disease in wheat. Pest Management Science, 2019; 75(6):1546–1555.

Wahla S H, Cheema M J M, Arshad M, Chaat A A, Siddique S A. Spray uniformity testing of unmanned aerial spraying system for precise agro-chemical applications. Pakistan Journal of Agricultural Sciences, 2019; 56: 897–903.

Guo S, Li J Y, Yao W X, Zhan Y L, Li Y F, Shi Y Y. Distribution characteristics on droplet deposition of wind field vortex formed by multi-rotor UAV. Plos One, 2019; 14(7): e0220024. doi: 10.1371/journal.pone.0220024.

Zhu H, Jiang Y, Li H Z, Li J X, Zhang H H. Effects of application parameters on spray characteristics of multi-rotor UAV. Int J Precis Agric Aviat, 2019; 2(1): 18–25.

Chen S D, Lan Y B, Li J Y, Zhou Z Y, Liu A, Mao Y D. Effect of wind field below rotor of unmanned helicopter on droplet deposition distribution of aerial spraying. Int J Agric & Biol Eng, 2017; 10(3): 67–77.

Zhang P, Wang K J, Qiang L Y, He S L, Yi S L, Xie R G, et al. Droplet distribution and control against citrus leaf miner with UAV spraying. International Journal of Robotics and Automation, 2017; 32(3): 299–307.

Jee S, Jeon B, Cho H C. Implementation of aerial application system for application uniformity. The Korea Academia-Industrial Cooperation Society, 2016; 17(1): 597–604. (in Korean)

Xue X Y, Lan Y B, Sun Z, Chang C, Hoffmann W C. Develop an unmanned aerial vehicle based automatic aerial spraying system. Computers and Electronics in Agriculture, 2016; 128: 58–66.

Koo Y M, Bae Y H, Seok T S, Shin S K, Park H J. Tail rotor design and thrust test for a roll-balanced agricultural unmanned helicopter. Journal of Biosyistems Engineering, 2010; 35: 302–309.

Hunter J E, Gannon T W, Rochardson R J, Yelverton F H, Leon R G. Coverage and drift potential associated with nozzle and speed selection for herbicide applications using an unmanned aerial sprayer. Weed Technology, 2020; 34: 235–240.

Wang G B, Han Y X, Li X, Andaloro J, Chen P C, Hoffmann, W C, et al. Field evaluation of spray drift and environmental impact using an agricultural unmanned aerial vehicle (UAV) sprayer. Science of the Total Environment, 2020; 737: 139793. doi: 10.1016/j.scitotenv.2020.139793.

Bird S L, Esterly D M, Perry S G. Off-target deposition of pesticides from agricultural aerial spray applications. Journal of Environmental Quality, 1996; 25(5): 1095–1104.

Chechi A, Roehrig R, Piton B. The combined use of spray volumes and droplet sizes in the chemical control of Asian soybean rust in cultivars with different leaf area indices. Crop Protection, 2020; 136: 105212. 10.1016/j.cropro.2020.105212.

Knoche M. Effect of droplet size and carrier volume on performance of foliage-applied herbicides. Crop Protection, 1994; 13(3): 163–178.

Butts T R, Samples C A, Franca L X, Dodds D M, Reynolds D B, Adams J W, et al. Spray droplet size and carrier volume effect on dicamba and glufosinate efficacy. Pest Management Science, 2018; 74(9): 2020–2029.

Berger S T, Dobrow M H, Ferrell J A, Webster T M. Influence of carrier volume and nozzle selection on palmer amaranth control. Peanut Science, 2014; 41(2): 120–123.

Ferguson J C, Chechetto R G, Adkins S W, Hewitt A J, Chauhan B S, Kruger G R, et al. Effect of spray droplet size on herbicide efficacy on four winter annual grasses. Crop Protection, 2018; 112: 118–124.

Creech C F, Henry R S, Werle R, Sandell L D, Hewitt A J, Kruger G R. Performance of postemergence herbicides applied at different carrier volume rates. Weed Technology; 2015; 29(3): 611–624.

Creech C F, Moraes J G, Henry R S, Luck J D, Kruger G R. The impact of spray droplet size on the efficacy of 2,4-D, atrazine, chlorimuron-methyl, dicamba, glufosinate, and saflflufenacil. Weed Technol, 2016; 30: 573–586.

Cao L D, Cao C, Wang Y, Li X H, Zhou Z L, Li F M, et al. Visual determination of potential dermal and inhalation exposure using allura red as an environmentally friendly pesticide surrogate. ACS Sustainable Chemistry & Engineering, 2017; 5(5): 3882–3889.

Wang S L, Song J L, He X K, Song L, Wang X N, Wang C L, et al. Performances evaluation of four typical unmanned aerial vehicles used for pesticide application in China. Int J Agric Biol Eng, 2017; 10(4): 22–31.

Ebert T A, Taylor R, Downer R A, Hall F R. Deposit structure and efficacy of pesticide application. 1: Interactions between deposit size, toxicant concentration and deposit number. Pesticide Science, 1999; 55(8): 783–792.

Xiao Q G, Xin F, Lou Z X, Zhou T T, Wang G B, Han X Q, et al. Effect of aviation spray adjuvants on defoliant droplet deposition and cotton defoliation efficacy sprayed by unmanned aerial vehicles. Agronomy, 2019; 9: 217. doi: 10.3390/agronomy9050217.

Merrltt C R. The influence of form of deposit on the phytotoxicity of difenzoquat applied as individual drops to Avena fatua. Annals of Applied Biology, 2008; 101(3): 517–525.

Ramsdale B K, Messersmtth C G. Nozzle, spray volume, and adjuvant effects on carfentrazone and imazamox efficacy. Weed Technology, 2001; 15(3): 485–491.

Robert E E, William E H, Robert M H. Effect of venturi-type nozzles and application volume on postemergence herbicide efficacy. Weed Technology, 2001; 15: 75–80.

Bryant J E, Yendol W G. Evaluation of the influence of droplet size and density of bacillus thuringiensis against gypsy moth larvae (Lepidoptera: Lymantriidae). Journal of Economic Entomology, 1988; 81(1): 130–134.

Alm S R, Reichard D L, Hall F R. Effects of spray drop size and distribution of drops containing bifenthrin on tetranychus urticae (Acari: Tetranychidae). Journal of Economic Entomology, 1987; 80(2): 517–520.

Adams A J, Hall F R. Initial behavioural responses of aphis gossypii to defined deposits of bifenthrin on chrysanthemum. Crop Protection, 1990; 9: 39–43.

Bouse L F, Whisenant S G, Carlton J B. Aerial spray deposition on mesquite. Transactions of the ASABE, 1992; 35(1):51–59.

Lee A W, Miller P C H, Power J D, Cross J V, Gilbert A J, Glass C R, Taylor W A, Walklate P J, Western N M. The application of pesticide sprays to tomato crops. Aspects of applied biology, 2000; 57: 383–390.

Rincon V J, Sanchezhermosilla J, Paez F, Perezalonso J, Callejon A J. Assessment of the influence of working pressure and application rate on pesticide spray application with a hand-held spray gun on greenhouse pepper crops. Crop Protection, 2017; 96: 7–13.

Xiao Q G, Du R, Zhou T T, Han X Q, Wang G B, Fu W. Effects of alkyl ethyl sulfonate dosage on cotton defoliation efficacy sprayed by UAV. Int J Precis Agric Aviat, 2019; 2: 67–75.

Beresford L C, Roger D S, Keith R K, Robert E K. Efficacy evaluation of a reduced dosage of tebufenozide applied aerially to control spruce budworm (Choristoneura fumiferana). Crop Protection, 2005; 24(6): 557–563.

Xu D J, Gu Z Y, Xu G C, Xu X L, Dong Y X. Effects of droplet density and droplet size on control efficiency of chlorantraniliprole against cnaphalocrocis medinalis (Guenée). Scientia Agricultura Sinica, 2012; 45(4): 666–674.

Zhu H, Salyani M, Fox R D. A portable scanning system for evaluation of spray deposit distribution. Computers and Electronics in Agriculture, 2011; 76(1): 38–43.

Munthali D C. Biological efficiency of small dicofol droplets against tetranychus urticae (Koch) eggs, larvae and protonymphs. Crop Protection, 1984; 3(3): 327–334.

Munthali D C, Wyatt I J. Factors affecting the biological efficiency of small pesticide droplets against Tetranychus urticae eggs. Pesticide Science, 1986; 17(2) 155–164.

Pierce R A, Ayers P D. Evaluation of deposition and application accuracy of a pulse width modulation variable rate field sprayer. 2001 ASAE Annual International Meeting, Sacramento, USA, July 30-August 1, 2001.




Copyright (c) 2021 International Journal of Agricultural and Biological Engineering

Creative Commons License
This work is licensed under a Creative Commons Attribution 4.0 International License.

2023-2026 Copyright IJABE Editing and Publishing Office