Development and test of a multi-rotor plant protection drone for narrow spraying applications
Abstract
Unmanned aerial vehicle (UAV) wind field airflow is the main factor affecting spraying width and operational effect. Under the soybean and maize compound planting mode, the width of the spray droplets of UAV aerial spraying is easily sprayed on other crops around the target crop by mistake due to the influence of the wind field. In order to solve this problem, a narrow-width spraying UAV equipped with an airflow guidance device was developed in this study, which can achieve precise spraying on target crops within a narrow operation width and reduce the impact of droplet drift on surrounding non-target crops. The wind field of the flight platform was simulated via simulation software, and the wind field distribution characteristics corresponding to three sizes of the guidance device were analyzed. It was verified that the guidance device has a segmentation effect on the wind field, and the optimal size of the guidance device was determined as 0.92 m accordingly. Meanwhile, the installation position and quantity of nozzles were determined to be set at the position with the minimum airflow disturbance. The wind speed at measuring points with different angles on four diameters at five heights under the UAV hovering state was tested through bench tests, to further verify the simulation results and appropriately adjust the nozzle position according to the measured wind speed. Outdoor flight spraying tests were carried out, and the results showed that when the 0.92 m guidance device was applied at a flight altitude of 1.00 m, the effective spray width was only 1.46 m according to the droplet deposition density on the coated paper of three test collection belts. Under the maize-soybean composite planting pattern, the field spraying test yielded results of 18%-30% deposition rate in the maize area and 0.1%-1.6% in the soybean area with maize as the operational target. A predictive effect of wind field simulation on the installation position of nozzles where droplets suffer the least wind field disturbance under aerial spraying conditions was confirmed. The UAV wind field can be effectively segmented by the airflow guidance device, and the diameter of the droplet-laden airflow column can be reduced, thus realizing narrow-width spraying.
Keywords: narrow spraying, plant protection drone, downwash wind field guidance, CFD
DOI: 10.25165/j.ijabe.20261902.9472
Citation: Wang C Y, Kong Q X, Han J G, Han X, Lan Y B, Wang G B, et al. Development and test of a multi-rotor plant protection drone for narrow spraying applications. Int J Agric & Biol Eng, 2026; 19(2): 1–12.
References
[1] He J S. Application of plant protection drones for pest control in corn-soybean strip compound planting system. Agricultural Engineering Technology, 2024; 44（11）: 70–71. （in Chinese）
[2] Zhang T, Dong X, Yin S Z, Yang X J, Yan H R, Gong Q T, et al. Spraying performance of lightweight high clearance boom sprayer in soybean field. Transactions of the CSAM, 2016; 47（S1）: 182–188. （in Chinese）
[3] Shang Z Q. Design and experimental study on small electric sprayer for soybean self-propelled striping boom sprayer. Zhengzhou: Henan Agricultural University, 2021; 97p. （in Chinese）
[4] Wang R, Cao D L, Liu Y S, Jin J M. Design and test of self balancing precise fertilizer and pesticide applying machine. Journal of Agricultural Mechanization Research, 2019; 41（3）: 124–129. （in Chinese）
[5] Cheng S S. Design and experimental study of striping boom sprayer for soybean-maize strip intercropping. Zhengzhou: Henan Agricultural University, 2022; 53p. （in Chinese）
[6] Wang P, Kang Y H, Lee C G, Han X Z, et al. Development of an autonomous drone spraying control system based on the coefficient of variation of spray distribution. Computers and Electronics in Agriculture, 2024; 227: 109529.
[7] Sánchez-Fernández L, Barrera M, Martínez-Guanter J, Pérez-Ruiz M. Drift reduction in orchards through the use of an autonomous UAV system. Computers and Electronics in Agriculture, 2023; 211: 107981.
[8] Shan C F, Xue C, Zhang L C, Song C C, Kaousar R, Wang G B, et al. Effects of different spray parameters of plant protection UAV on the deposition characteristics of droplets in apple trees. Crop Protection, 2024; 184: 106835.
[9] Zhan Y L, Chen P C, Xu W C, Chen S D, Han Y F, Lan Y B, et al. Influence of the downwash airflow distribution characteristics of a plant protection UAV on spray deposit distribution. Biosystems Engineering, 2022; 216: 32–45.
[10] Yang F B, Xue X Y, Cai C, Zhou Q Q. Effect of downwash airflow in hover on droplet motion law for multi-rotor unmanned plant protection machine. Transactions of the CSAE, 2018; 34（2）: 64–73. （in Chinese）
[11] Zhang T, Yang X J, Dong X, Liu S M, Wang J J, Dou L J. Experiment on spraying performance of super-high clearance boom sprayer with air-assisted system. Transactions of the CSAM, 2012; 43（10）: 66–71. （in Chinese）
[12] Li R F, Han S K, Yang F B. Research on downwash flow and droplet distribution of four-rotor plant protection UAV coupling with wind field. Journal of Chinese Agricultural Mechanization, 2024; 45（7）: 81–86. （in Chinese）
[13] Fu Z Z, Guo L Z, Cheng L, Li Q R, Wei Y H. Droplet deposition characteristics and weed control effects of bentazone herbicide sprayed by plant protection drones in oat fields. Acta Agriculturae Universitatis Jiangxiensis, 2024; 46（5）: 1221–1232. （in Chinese）
[14] Lan Y B, Shan C F, Wang Q Y, Liu Q, Yang C L, Xie Y J, et al. Effects of different spray additives on droplet deposition characteristics during plant protection UAV spraying operations. Transactions of the CSAE, 2021; 37（16）: 31–38. （in Chinese）
[15] Wang G B, Han Y X, Li X, Andaloro J, Chen P C, Hoffmann W C, et al. Field evaluation of spray drift and environmental impact using an agricultural unmanned aerial vehicle （UAV） sprayer. Science of The Total Environment, 2020; 737: 139793.
[16] Zhang H Y, Lan Y B, Wen S, Xu T Y, Yu F H. Research progress in rotor airflow model of plant protection UAV and droplet motion mechanism. Transactions of the CSAE, 2020; 36（22）: 1–12. （in Chinese）.
[17] Zhang H, Qi L J, Wu Y L, Musiu E M, Cheng Z Z, Wang P. Numerical simulation of airflow field from a six-rotor plant protection drone using lattice Boltzmann method. Biosystems Engineering, 2020; 197: 336–351.
[18] Lei Y, Huang Y, Wang H. Effects of wind disturbance on the aerodynamic performance of a quadrotor MAV during hovering. Sensors, 2021; 2021: 6681716.
[19] Liu Y, Chen B, Zhang J C, Zhang X, Chen X B. Research and development of wind resistance test system for plant protection UAV. Journal of Jiangsu University （Natural Science Edition）, 2020; 41（3）: 346–352. （in Chinese）
[20] Wang B, Zhang Y, Wang C S, Teng G F. Droplet deposition distribution prediction method for a six-rotor plant protection UAV based on inverse distance weighting. Sensors, 2022; 22（19）: 7425.
[21] Wang T, Wen S, Lan Y B, Zhang H Y, Yin X C, Zhang J T. Prediction model for the downwash flow field of single-rotor plant protection UAV using PINNs. Transactions of the CSAE, 2023; 39（6）: 83–91. （in Chinese）
[22] Li H Z, Zhu H, Jiang Z H, Lan Y B. Performance characterization on downwash flow and spray drift of multirotor unmanned agricultural aircraft system based on CFD. Int J Agric & Biol Eng, 2022; 15（3）: 1–8.
[23] Shi X, Gao S C, Yang D B, Yuan H Z, Yan X J. High-throughput quantification of allura red trace used in determining pesticide deposition utilization by microplate reader. Modern Agrochemicals , 2021; 20（1）: 1–7. （in Chinese）
[24] Liu X C, Meng Y H, Zhang Y F, Chen W, Du X T, Hu H Y. An OpenCV-based method for direct detection of droplet deposition parameters on cotton leaves. China Cotton, 2024; 51（10）: 9–14. （in Chinese）
[25] Xie Y J, Wang G B, Wang B J, Shan C F, Lan Y B. Selection of nozzle type and parameter optimization in herbicide spraying process of plant protection UAV. Journal of Chinese Agricultural Mechanization, 2021; 42（4）: 61–69. （in Chinese）.
[26] Ma K, Zhang Z Y, Dong X Y, Qiu B J. Design and test of a portable droplet deposition detection system. Journal of Agricultural Mechanization Research, 2023; 45（5）: 49–54. （in Chinese）
Downloads
Published
How to Cite
Issue
Section
License
Copyright (c) 2026 International Journal of Agricultural and Biological Engineering
This work is licensed under a Creative Commons Attribution 4.0 International License.
IJABE is an international peer reviewed, open access journal, adopting Creative Commons Copyright Notices as follows.
Authors who publish with this journal agree to the following terms:
- Authors retain copyright and grant the journal right of first publication with the work simultaneously licensed under a Creative Commons Attribution License that allows others to share the work with an acknowledgement of the work's authorship and initial publication in this journal.
- Authors are able to enter into separate, additional contractual arrangements for the non-exclusive distribution of the journal's published version of the work (e.g., post it to an institutional repository or publish it in a book), with an acknowledgement of its initial publication in this journal.
- Authors are permitted and encouraged to post their work online (e.g., in institutional repositories or on their website) prior to and during the submission process, as it can lead to productive exchanges, as well as earlier and greater citation of published work (See The Effect of Open Access).
